Electric golf cart is completely powered by batteries. A fully charged battery will not freeze until 60-70 below zero whereas a discharged battery can freeze at 20 degrees above zero. As battery dischargers, the acid turns into water by the basic chemical nature of the lead acid battery. The more discharger, the more water and the more likely it is to freeze. Also a dirty, acid covered battery will self-discharge at a faster rate than a clean treated battery, even in cooler temperatures. In winter, the weather is always very cold, and people may not go out to play golf as frequently as in the summer. Hence, the golf cart might be less used in winter, so it will be stored anyway. But how should you store the cart? Is it just putting in the garage? Of course, the answer is not.
First of all, you should check, clean tighten and treat all the golf cart batteries terminal connections. Clean the batteries and ensure that all the cell caps are snugly attached. Then unplug the charger and wash the battery compartment. Start on one side of the golf cart and spray Battery Neutralizer all over the tops of the batteries. Be sure to spray between the batteries, down on the battery racks, and the inside walls of the body panels, if they are metal. Use an old paintbrush to scour all the battery tops and sides. Water from a garden hose using plain water, or use a solution of Baking Soda (about 2 tablespoons to 1 gallon of water) to neutralize the acid. Be sure the cables are tight to the post. Carefully wriggle each cable end side-to-side and then gently up & down. There should be no looseness or sideways movement. If your battery terminals are badly corroded, you will need to do some serious cleaning.
Then check the water levels in each cell. Use distilled water to fill and be sure the electrolyte (water) in each battery cell is above the plates. In cold climates, when the cart will be left uncharged for several months, leave the water level a little low. This raises the specific gravity of the acid, which will help prevent freezing. A lead acid battery keeps much better in the cold than in the heat, as long as the charge stays up.
You’d better give your batteries a full charging because a full charged battery will not freeze until 60 to 70 below zero whereas a discharged battery can freeze at 20 degrees above zero. Besides, don’t leave your electric golf cart plugged into the charger for extended periods of time. After the charge is done, unplug the charger from the cart and from the wall. Finally, leave the cart in Neutral and turn the key off. Either way, scotch the wheels, so you can leave the hill brake released. This prevents strain on the cables and the brake shoes can’t lock to the drums.
Giving your electric golf cart a proper storage will let you use for longer time. If you want to read more about golf cart, please visit http://www.marshell.net
